"After driving this van for the last 5 years, I can say it has been a great truck.
I have driven the Ford van, and we have many in our company, but any of GM vans
out handle the Fords anyday. After our company chnaged to Ford for an entire fleet replacement, we have now changed back to GM/ Chevrolet, and I am waiting on the arrival of an 08. All I can say is Thank God. The new grill on the fords look great but you'll never be as happy with it. Pick GM and regret it!"
"Have owned this 2500 van for nearly 4 years and !5000 mi. No repairs of any kind to date, just scheduled maint at dealer. Transmission sometimes slips a little when starting off. Not bad enough to have repaired yet. Ride is rough but seats are very comfortable so ride is OK overall. Noise level is higher than I like but there are no unusual squeaks or rattles, just engine and road noise. This has been the best american made vehicle I've ever owned."
"very good cond. Only put 6000 miles on it in past two years. Had a small car when it was purchased and now have a buick rendezvous with more room and don't use the van for travel any more. Only repair done to it has been fuel filter replacement. Runs good."
"I have driven a lot of vans in my 27 years of construction. I would have to say that this is the second best that I have driven. First would have to go to my '96 Dodge Ram 250. That van was at 260,000 miles when I sold it and the motor had never been touched. I did have to have the tranny rebuilt. My Express 2500 runs great, gets OK mileage (between 16-17mpg), hauls loads with no problem, and also looks good. I have 120k on it now and have had no problems. No transmission issues and no motor noise. Hope this will make it past the 250k!"
"Bought this 2003 new.No problems,EXCEPT when the van is loaded,going down a 6+% grade,it can be very exciting: Violent shaking,totally out of control,scary ride.If you have a weak heart,stay out of these circumstances.Talked with GM about this,went to several dealers,never got an answer. Bottom line,I do not haul a load with this van into the Smokies,or anywhere else where I expect to find steep grades. (I use my Dodge Sprinter for the mountains.)It (Chevy) gets as much as 15 MPG. Not good,but when I bought it,not bad.It has been very reliable after 43K miles.Have had numerous Chevy's and have been pleased with most of them. Wouldn't buy another one.The front end problem cured me forever."
"Getting rid of this van sorry to say two reasons, the gas mileage, and the gas mileage! iT HAS HAD MORE LITTLE REPAIRS THAN ANY OTHER VEHICLE I HAVE EVER OWNED OVER THE LAST 38 YEARS! Power is excellant, the transmission shifts are sloppy. The interior plastic does not fit well. It does ride nice for a 3500 (1-ton truck) got to give it that. 13 miles to the gallon with the 6.0 stinks."
have owned 7 vans, 5 new, this one ordered with the 7.4L gas, ext. van,
heavily optioned, put on 86,000 smiles, wonderful vehicle, will always
be remembered fondly, and compared to as the gold standard. My trade-in
value was phenominal, and replaced with a new Avalance, since 4WD is now an absolute
necessity. I miss that van tremendously!"
"We have a 1998 Global Express conversion van. Despite excellent maintenance, the engine blew up at 120,000 miles. The engine is not repairable. The rear tail lights on mine (and others I have seen) must have some sort of a short. Have to replace the entire socket fixture to correct. The doors rattle incessantly. The upper dash board crakced under the heat in Florida. This is not a good vehicle to own. Save yourself a lot of aggravation and look for something different."
"We had a 1995 G20 Chevy Van and loved it. Moved to a Dodge Van in 2000 and went back to a Chevy Express in 2002. The styling and comfort is fabulous. It is very roomy and served all the needs we've ever had. However, with only 76,000 miles on it we have replaced the transmission twice, had problems with radio static, replaced the fuel filter, had some of the window treatments break and the passenger door continually rattles no matter how much we try to get it fixed or fix it ourselves. I don't trust this van for any long distance or vacation driving."
"I was given this van for work replacing our Dodge Vans. I can honestly say that the van is styled well. Engineers must have been service work oriented on this design. It is comfortable, has plenty of power for a V6, and rides well. I can even haul my boat with it after work and get more out of it. Goes great in the snow as well. My only complaint is the side doors need a better design on the hinges, have to oil weekly to keep them moving freely."
"I have been on several long road trips with two adults and five kids in the van and we loved every minute of it. It has the room for the people to spread out and lots of room for luggage. The next vehicle I buy will be smaller because the kids have moved out and I don't need the space anymore but this van was good for us when they were home!!!"